How to replace the air filter on a riding lawn mower
This DIY riding mower repair guide gives step-by-step instructions for replacing the air filter on riding lawn mowers. The air filter traps dirt from air going into the carburetor. If the air filter is clogged with dirt, the carburetor won't get enough air to mix with the fuel for combustion. A dirty air filter could be the problem if the engine stalls after starting or if it runs rough or sputters. Check the air filter regularly and replace it with a manufacturer-approved replacement part if it’s dirty. While you’re replacing the main air filter, it’s a great idea to install a new foam pre-filter too.
Follow the steps in this repair guide and video to replace the air filter on common Briggs & Stratton engines that power Craftsman, Husqvarna, John Deere, Ariens, Toro, MTD, Troybilt, Murray, Snapper and Cub Cadet riding mowers and lawn tractors.
This video explains how to replace the air filter on a riding lawn mower.
Instructions
- 01.
Disconnect the spark plug
Park the tractor on a level surface and set the parking brake.
Turn the ignition switch off and remove the key.
Let the engine cool.
Wear work gloves to protect your hands.
Lift the tractor hood and disconnect the spark plug wire.
Tip: Disconnect both spark plug wires if your tractor has 2 cylinders.
PHOTO: Disconnect the spark plug.
- 02.
Remove the old air filter
Rotate the air filter cover’s retaining knobs counterclockwise to release them and then pull off the air filter cover.
Release the air filter from the intake tube and pull out the filter and foam pre-filter.
PHOTO: Remove the air filter cover.
- 03.
Install the new air filter
Slide the foam pre-filter onto the air filter.
Connect the new air filter to the intake tube and slide the filter into the housing.
Reinstall the air filter cover and rotate the retaining knobs clockwise to lock the cover in place.
Tip: Replace the foam pre-filter when you replace the air filter.
PHOTO: Install the new air filter.
- 04.
Reconnect the spark plug
Reconnect the spark plug wire and lower the tractor hood.
Tip: Reconnect both spark plug wires if your engine has 2 cylinders.
Most common symptoms to help you fix your riding mowers & tractors
Choose a symptom to see related riding mower and lawn tractor repairs.
Main causes: faulty battery, bad alternator…
Main causes: damaged cutting blade, worn deck pulley, damaged mandrel pulley, loose fasteners on mower deck components…
Main causes: damaged tie rods, bent or worn wheel spindle, worn front axle, damaged sector gear assembly…
Main causes: worn or broken blade belt, broken belt idler pulley, blade clutch cable failure, bad PTO switch, damaged ma…
Main causes: punctured tire or inner tube, leaky valve stem, damaged wheel rim…
Main causes: engine overfilled with oil, leaky head gasket or sump gasket, damaged carburetor seals, cracked fuel pump, …
Main causes: clogged carburetor, damaged flywheel key, dirty spark plug, stale fuel, improper valve lash, engine needs a…
Main causes: shift lever needs adjustment, neutral control needs adjustment…
Main causes: worn or broken ground drive belt, bad seat switch, transaxle freewheel control engaged, transaxle failure, …
Most common repair guides to help fix your riding mowers & tractors
These step-by-step repair guides will help you safely fix what’s broken on your riding mower or lawn tractor.
How to replace the starter motor on a riding lawn mower
If you hear the solenoid click but don’t hear the starter motor spin when you turn the key, follow these steps to replac…
How to rebuild a riding lawn mower carburetor
Get your sputtering carburetor running smoothly in 60 minutes.…
How to replace a riding lawn mower rear tire
Your mower can’t run on a damaged rear tire. Here’s how to install a new one.…
Effective articles & videos to help repair your riding mowers & tractors
Use the advice and tips in these articles and videos to get the most out of your riding mower or lawn tractor.
Learn about all the convenient features on our Sears PartsDirect website that make your parts purchases easier.…
Get answers to frequently asked questions about Sears and Sears PartsDirect.…
Check the starter solenoid, starter motor, wiring, battery and engine.…